Garage floor concrete in Dixon CA - a level slab on ground that's packed first
Cracked, sinking or dusty garage floor? We dig out, pack the base and pour a new slab that stays flat.
- Licensed and insured.
- Free in-person estimates.
- Replies within 1 business day.
What's involved in tearing out and pouring a new garage floor?
Garage floor concrete is a new slab poured inside your garage in Dixon, usually after we break out the old one and dig out and pack the ground under it. It's flatwork, the flat slab jobs like floors, patios and driveways, and California's contractors board counts forming, pouring and finishing it as concrete contractor work. After the pour, the slab needs time to cure before the garage goes back to full use.
Most calls start with an old floor that's broken up, low by the door or shedding dust every time you sweep, or with a new garage that needs its slab done right the first time. The price moves with the garage's size, whether there's an old slab to haul out and how much the ground needs before we pour, and the schedule turns on permit steps, the weather and the cure before you load it. Your own number comes from the estimate when I come out and look, and if the drive outside is in the same shape, we do concrete driveways too.
How do you know your garage floor needs replacing?
Cracks that keep growing
A hairline crack is normal, but one that widens or has one side higher than the other usually means the ground under it moved. Left alone, water gets in, more dirt washes out and the pieces tilt further.
Low spots by the door
A dip near the door or a drain often means the base was raked level instead of dug out and packed, so it settled with the dirt. Water sits there, and the longer it sits, the softer the ground below gets.
Dust, chips or peeling
A floor that turns powdery, chips at the edges or sheds its coating usually had a weak top from the start, often from a hot pour or a rushed finish. It keeps flaking under tires and dropped tools, so it only gets rougher.
Often paired with a new garage floor
Decorative concrete
Once the garage is new, an old gray entry or side patio stands out, and colored or patterned concrete there can make the whole front look finished.
Concrete retaining walls
Garages cut into a slope can take runoff and loose soil against the slab, and a wall that holds the hillside back keeps that ground in place.
How we pour garage floor concrete
I start by asking how you use the garage and checking where water runs, because the floor should fall toward the door and away from the house. Then our crew breaks out the old slab, digs out the soft dirt and packs the subgrade, the ground the slab sits on, in layers, utility trenches included, since a large share of the soil across Solano County is clay that swells when wet and shrinks when it dries. We set rebar, steel that holds cracks tight so pieces don't drift apart, pour early on hot days so the top doesn't come out weak and dusty, and cut control joints, planned grooves that give the slab a place to crack, around the inside corners at the door and any posts. If the budget's tight, I'd rather you skip a fancy finish than cut the base, because nobody sees the base on day one but it decides whether the floor stays flat.
If you want a coating on the floor later, tell me up front, because a new slab can look dry before it's ready, so we plan the wait and the prep with you. When the garage sits against a slope, concrete retaining walls keep the dirt where it belongs, and if you want color or pattern on the approach, we pour decorative concrete as well.
Bare slab, smooth or broom finish
Most garages get a smooth troweled top that sweeps clean, and a broom finish, a light brushed texture for grip, works where the floor gets wet near the door. It suits a garage used for parking and storage, where you want a sound, plain floor.
Slab planned for a coating
If the garage will be heated or cooled, coated, or opens into the house, a vapor barrier sheet under the slab can matter, and any pipe that comes up through it gets sealed so it keeps working. It suits anyone planning epoxy or turning the garage into a gym or shop.
Get a garage floor estimate at your house
Send the form and we'll reply within one business day to set a time for me to come out. The estimate is free with no obligation, and calling (707) 640-8084 works too.
Call (707) 640-8084Why Dixon homeowners call Premier Dixon Concrete for garage floors
I come out to every job
I look at every job myself before I price it, and I'm on site running our crew when the work gets done. The person who planned your base is the one watching it get packed.
Licensed and insured on your job
Premier Dixon Concrete is licensed and insured. You're letting a crew and heavy equipment into your garage, so it should be one that's covered while we work.
Based in Dixon since 2023
I started the business here in 2023, and we work across Vacaville, Davis, Woodland, Fairfield and the Sacramento side. Working on the county's clay ground is why base prep is the first line I price.
A garage floor is only as good as the ground under it, so tell us about your garage and I'll come take a look.
What happens after you call about a garage floor in Dixon?
Call or send the form
Call (707) 640-8084 between 7 AM and 11 PM any day, or send the form. We set a time for me to come see the garage.
I walk the garage with you
I look at the floor and the ground around it and ask how you'll use the garage and whether a coating is in your plans. You get a price for your floor and what it covers, base work included, so you can see where the money goes.
We permit, prep and pour
If your floor needs a permit, we pull it and set up the inspections, and when we're not sure we ask the city before we start, whose building counter is open 8:30am to 4:30pm if you want to ask too. Then we prep the ground, pour, and I walk you through curing before we leave.
Common questions
How much does it cost to replace a garage floor in Dixon?
The price comes down to the garage's size, whether there's an old slab to break out and how much work the ground needs before we pour. A vapor barrier, a thicker slab or more steel for a shop raises it, and a plain finish over a sound base keeps it lower. I'll give you your number once I've seen the garage.
How long until I can use my garage after a new concrete floor?
A Sacramento slab guide says the slab should be walkable within 48 hours and suggests waiting a week before heavier loads go on it, while a full cure takes 28 to 30 days. Curing is the slow hardening that gives concrete its strength, so plan where the heavy things go for that first week.
When can I put an epoxy coating on a new garage floor?
Not until someone has checked the floor's moisture and surface texture, which is what tells you a new slab is ready for epoxy or polyaspartic. Oil, curing compounds and moisture left in the slab can all weaken how well a coating sticks, so the wait and the surface prep belong in the plan from the start.
How much can a contractor ask for up front in California?
Under the state contractors board's rules, no more than $1,000 or 10 percent of the total contract price, whichever is less. After that, each payment is listed in the contract and tied to work already done or materials delivered, so you can match what you pay to what you see on site.
Where do I apply for a building permit in Dixon?
Permit applications go to the City of Dixon Building Division, and unless you've made special arrangements ahead of time, they're submitted through the city's Dixon Civic Access online system. You can reach the division at buildingdivision@cityofdixonca.gov or (707) 678-7005, option 2, and the city also posts a policy on work exempt from permits, so it's worth asking where a garage floor falls.
What causes a garage floor to crack, and will a new one crack too?
Most bad cracks come from a base that settled or from joints that were cut late or skipped, so the slab split where nobody chose. A new floor can still get fine shrinkage cracks, but a packed base and joints in the right places keep them small and mostly inside those grooves.
Plan your new garage floor with us
Call (707) 640-8084 or email info@concretedixon.com with your garage's size and whether you plan a coating or the garage opens into the house, so I know what to check when I come out.